欢迎光临南京国都地坪科技有限公司官网!

企业邮箱 收藏本站收藏本站 网站地图

国都地坪

南京国都地坪科技有限公司为客户提供优质全面的地坪系统设计及地面问题解决方案
全国咨询热线:137-7148-9633

热门搜索关键词: 环氧地坪  南京环氧地坪  无锡环氧地坪  苏州环氧地坪  无锡环氧地坪工程  无锡环氧地坪施工  

技术知识 Classification
联系我们
服务热线:
137-7148-9633

手机:137-7148-9633

传真:0510-8585.1922

QQ:173558977

地址:南京市秦淮区中山东路288号

当前位置:首页 > 技术知识 > 渗透地坪 > 环氧地坪漆的施工改造要注意哪些问题

环氧地坪漆的施工改造要注意哪些问题

文章出处:南京国都地坪科技有限公司   发布时间:2019-9-1 8:19:31   浏览:7
环氧地坪漆施工人员早检查无锡环氧地坪过程时,发现基础地面强度与平整度较差,但是面层表面未出现开裂,起鼓。认为一般只需要旧环氧地坪漆涂层全部铲掉后进行打磨,而这次打磨需要有点深度。 防滑性能是环氧地坪漆施工验收的一个重要指标 环氧地坪漆具有提升表面摩擦系数的性能,因此做好无锡环氧地坪之后,可以得到更好的防滑效果。按照科学的理论,判断地面是否防滑,主要是通过测量地面的摩擦系数是否足够大来判定。而在日常经验中,经常会以物体表面的光滑程度来判断是否防滑,这对于…

环氧地坪漆施工人员早检查无锡环氧地坪过程时,发现基础地面强度与平整度较差,但是面层表面未出现开裂,起鼓。认为一般只需要旧环氧地坪漆涂层全部铲掉后进行打磨,而这次打磨需要有点深度。在我们的生活中,环氧地坪漆是较为常见的一类涂漆了,不管是在各个企业的车间内,还是各个教育机构的教室内,我们都是可以看到它的存在,它还具备着防滑,防尘等优点,那么我们在施工的时候要注意哪些问题呢?

When the epoxy floor paint builders checked the epoxy floor process early, they found that the strength and smoothness of the foundation floor were poor, but the surface did not crack and bulge. It is considered that only the old floor paint coatings need to be shoveled off and polished, and this polishing needs a little depth. In our life, epoxy floor paint is a more common type of paint, whether in the workshop of various enterprises, or in the classroom of various educational institutions, we can see its existence, it also has the advantages of anti-skid, dust-proof, so what problems should we pay attention to in the construction? 

环氧地坪漆的施工注意要点

Key Points for Construction of Epoxy Floor Paint

1、施工环境、搬运到施工现场的材料务必放在能够避免风、雨以及直光的地方。如阳光直接晒到施工面上,在基层中或还没有完全硬化的涂膜里含有的空气离子会因排出不畅而产生小气孔,因此要用报纸或塑料布盖住整个窗户。

1. The construction environment and materials to be transported to the construction site must be placed where wind, rain and direct light can be avoided. If the sunlight is directly exposed to the construction surface, the air ions contained in the basic layer or in the film which has not yet been completely hardened will cause small air holes due to poor discharge, so the whole window should be covered with newspapers or plastic sheets.

并且做到施工期间膜完全硬化期间应把门、窗、缝隙等透风处用护面胶带封好。同时需防止缝隙吹来的风带进尘土,一定不应在低于5℃的环境下施工,如有可能可开暖气或空调,下雨时把敞开部分都关闭一避免潮气影响施工面但不要阻碍通风。

In addition, during the construction period, when the membrane is completely hardened, the ventilation areas such as doors, windows and crevices should be sealed with protective tape. At the same time, it is necessary to prevent the wind from blowing into the crevice from bringing dust. It should not be constructed under the environment of less than 5 C. If possible, heating or air conditioning can be turned on. When it rains, the open part should be closed to avoid dampness affecting the construction surface, but do not hinder ventilation.

2、安全卫生管理方面的要求也很重要。从事施工的人员须经专门培训,对化学产品有一定的知识;施工时须穿工作服、工作鞋、配劳防用品;各种材料不小心沾到皮肤上有时会损伤皮肤,尽快用肥皂清洗干净,严重的送医院救治。

2. Safety and health management requirements are also important. Personnel engaged in construction must be specially trained and have a certain knowledge of chemical products; during construction, they must wear work clothes, work shoes and anti-labor supplies; when various materials are accidentally touched on the skin, they sometimes damage the skin. They should be cleaned with soap as soon as possible, and seriously sent to the hospital for treatment.

各种材料不准接触任何水分(水性环氧地坪涂料除外),因环氧地坪材料中含微量的可燃物,施工现场严禁烟火,现场的材料不准放置在阳光直接照射的地方;施工工具需定期检查,专人保养、保持清洁;施工现场应有明显标识,严禁无关人员进入。

All kinds of materials are not allowed to touch any moisture (except water-borne epoxy floor coating), because epoxy floor materials contain trace combustibles, fireworks are strictly prohibited at the construction site, and materials on the site are not allowed to be placed in places directly exposed to sunlight; construction tools should be inspected regularly, maintenance and cleaning by specialists; construction site should have clear standards. Understanding, no unrelated personnel are allowed to enter.

3、关于质量管理规定,施工之前施工技术人员要确认以下项目:基层面积及基面状态,选择材料和施工结构,熟悉材料说明书、配比、用量。

3. With regard to quality management regulations, before construction, construction technicians should confirm the following items: base area and base surface condition, select materials and construction structure, and be familiar with material specifications, proportioning and dosage.

施工之后施工技术人员要确认有没有明显抹痕、气孔、颗粒、桔皮等缺陷,有没有颜色不均及其他涂膜缺陷,颜色是否与样本一样、有无色差,涂膜上一否按正常规律硬化(用指甲来简单判断);施工人员应严格按每一步施工公共执行,发现有异样应找出原因并记录防止再发生,如不能解决应立即向技术人员汇报。

After construction, the construction technicians should confirm whether there are any obvious defects such as smear marks, air holes, granules, orange peel, uneven color and other film defects, whether the color is the same as the sample, whether there is color difference, whether the film is hardened according to the normal law (simple judgement with nails); the construction personnel should strictly follow every step of construction. Public execution should find out the reasons for the anomalies and record them to prevent recurrence. If they are not solved, they should report to the technical personnel immediately.


环氧地坪漆的改造该如何正确进行

How to Correctly Modify Epoxy Floor Paint

环氧环氧地坪的使用范围正不断扩大,例如工业厂房、停车场等场所皆能一睹环氧地坪的风采。而正常的环氧地坪一般使用寿命为5—8年,而在使用的这段时间内,要注意环氧地坪的养护。而如果在精心养护多年后,环氧地坪工程出现了问题,那么就意味着你该对旧环氧地坪工程进行旧地面翻新改造了。那么怎样来进行翻新改造呢?

The use of epoxy floors is expanding, such as industrial plants, parking lots and other places can see the elegance of epoxy floors. Normal epoxy flooring service life is 5 - 8 years, and in the use of this period of time, attention should be paid to the maintenance of epoxy flooring. If, after years of careful maintenance, problems arise in the epoxy flooring project, it means that you should renovate the old epoxy flooring project. So how to carry out renovation and transformation?


环氧地坪漆的施工注意

Construction Attention of Epoxy Floor Paint

并非所有的旧环氧地坪工程都需要进行改造,而主要是针对一些机械的运行和很多车辆的碾压,而使得环氧地坪漆的亮度出现严重下降。还有一些停车场地坪出现的严重脱落刮痕的,那么对于这些区域则需要下“重药”进行翻新改造了。

Not all old epoxy flooring projects need to be reformed, but mainly for the operation of some machinery and the rolling of many vehicles, resulting in a serious decline in the brightness of epoxy flooring paint. There are also some parking lot floors with severe scratches, so these areas need to be renovated with "heavy medicine".

而对于不同“受伤”程度,翻新改造的力度是不一样的。 旧无锡环氧地坪工程轻度划伤如果在环氧材料基础表面的时候,发现其基础地面的强度,平整度好,也没有开裂,只是表面上受了点“轻伤”那么处理方式就比较简单。只要把旧地坪漆面层打磨掉,而后清理干净旧环氧地坪表面之后,可以上一层环氧中涂即可。

For different degree of "injury", the strength of renovation and transformation is different. If the slight scratches of the old epoxy floor project are found on the surface of the epoxy material foundation, the strength, flatness and cracking of the foundation ground are good, but the surface is slightly damaged, the treatment method is relatively simple. As long as the surface of the old epoxy floor is polished, and then the surface of the old epoxy floor is cleaned up, it can be coated with epoxy.


下一篇:防滑性能是环氧地坪漆施工验收的一个重要指标 上一篇:环氧地坪涂装刷涂的施工方法

环氧地坪漆刷涂是指人工利用漆刷蘸取涂料对地面进行涂装的方法。其优点是:工具简单,施工简便,易于掌握,灵活性强,适用性强,节省涂料;对于边角、沟槽、机器设备底座等特殊位置和狭窄区域,其他施工方式难以涂装的部位,常采用手工刷涂方法施工。…

如何解决环氧地坪基面平整度超出范围

环氧地坪漆是地面的保护膜,它拥有较高的附着力和负载性,并兼具强韧耐磨、凭证光洁、成本经济、易清洁等有点。环氧地坪漆的厚度可以是0.5~5mm不等,相对于水泥混凝土几面5~25cm是很薄的一层,所以它的耐压和平整性主要还是依靠混凝土基面。一般来说,…

使用油漆刷施工环氧地坪漆容易出现的问题

环氧地坪漆涂装中常用的刷涂工具油漆刷是用羊毛、狼毛等加合成纤维做成的。但是在进行环氧地坪漆刷涂时常常出现一些问题,就是环氧地坪易产生刷痕、失光、流挂、图层不匀、起粒、粗糙等环氧地坪涂装缺陷。地坪产生刷痕和失光的原因:paintbrushesare…

客户选择环氧地坪应从哪方面考虑

环氧地坪如今在许多的家居装修、地下车库、工厂、市政等领域被大量的运用,它具有耐腐蚀性能好、耐摩擦、防腐蚀等特点,因此它属于一种功能性涂料。那么我们在选择环氧地坪的时候应该从哪些方面去考虑呢?接下来我们就和大家一起讨论这个话题。epoxy…

环氧地坪针产生气泡的原因和解决方法

环氧地坪如今被常用于地下车库、化工能源、市政建设、家庭装修等行业中,在和一般的涂料相比,它具有环保性能好、耐磨擦、耐腐蚀等特点。不过相信大家在使用环氧地坪的时候都会发现这样一种现象,就是涂料涂刷后有许多细小的类似于针孔状的原点,这是…

环氧地坪漆施工人员早检查无锡环氧地坪过程时,发现基础地面强度与平整度较差,但是面层表面未出现开裂,起鼓。认为一般只需要旧环氧地坪漆涂层全部铲掉后进行打磨,而这次打磨需要有点深度。

评论

  • 管理员刚刚

    暂无任何留言!